Car for dangerous freight class 1 Ford TRANSIT Jumbo 460’

Car ‘Ford TRANSIT Jumbo 460’

Engine - DuratorqTDCi turbodiesel 2.2 (/135 h.p.)
Ecological class – EURO 5
Transmission - Mechanical, 6 steps, ergonomic steering on the center extension housings, drive gear – rear, duo-pitch busbar of the rear axle.
Suspender – front independent, spring; Rear dependent, spring
Braking system - Hydraulic, with disk gears on all wheels, equipped with the ABS systems and electronic distribution of braking powers of EBD.
Electronic stability control system
ESP with the system of the help at start-off on bias HLA.
Loading capacity – 1800 - 2000 kg, fully loaded mass of the CU – 4600 kg.
Quantity of seats 2+1

FORD TRANSIT Jumbo 460 Package

• Front and rear mudflaps
• Wide side plastic moldings on all length of body
• Rear-view mirrors with electroresettings, heating up and signal of turning movement
• Front electrowindow regulators with function of opening / closing by one pressing from the driver's side
• The programmable prestarting heater with remote control
• Audiopreparation: 2 loudspeaker, conducting, antenna
• Route computer
• Anti-lock braking system (ABS)
• Stability control system (ESP)
• System of the help at start-off uphill (HLA)
• System of the help at emergency braking (EBA)
• Function of autolock-up of doors at start, unlocking at road accident
• Driver's seat with armrest, with mechanical resettings of sitting, textile upholstery
• Dual passenger seat, folding table in back of passenger seat, textile upholstery
• Full-size spare wheel
• Airbag of the driver
• Plastic bumper - black color
• High roof
• Twin rear wheels
• Hand-operated air conditioner
Completion upon the demand of DOPOG and UNECE Regulations No. 105:
1. The interior of the vehicle is divided into three compartments: - 1 compartment: driver's;
2 for transportation of СИ;
3 for transportation of ВВ;
2. Installation of two deaf strengthened partitions:
1 partition - between driver's compartment and compartment for transportation of СИ;
2 partition - between compartment for transportation of СИ and for transportation of ВВ
3. Completion of 1 compartment (driver's):
- Installation of digital tachograph with the GPS/GLONASS function and with the CIPF block;
Operating control of the independent fire extinguishing system Буран-2;
- Installation of the independent signaling;
- Installation of fastening under the fire extinguisher cylinder – 1 piece;
4. Completion 2 compartments (compartment for transportation of СИ):
- internal covering of compartment: plywood, smooth aluminum sheet of 1.5 mm; floor – plywood 10 mm corrugated aluminum of 1.5 mm with collaring; min. heater PPZh-200 brand plate (thickness – 50 mm;
- floor rings for fastening of freight – 4 pieces;
- plafond explosion-proof the PTE-Exd-15 brands (degree of protection of IP65) of internal illumination of body with isolation of wiring in aluminum housings – 1 set.;
- the installation of the Буран-2 fire extinguishing system with autonomous power supply from the regular accumulator and which is put in action from driver's cab – 1 set.;
- Installation of side aluminum sideboard;
5. Completion 3 compartments (compartment for transportation of ВВ):
- internal covering of compartment: plywood, smooth aluminum sheet of 1.5 mm; floor – plywood 10 mm corrugated aluminum of 1.5 mm with collaring; min. heater PPZh-200 brand plate (thickness – 50 mm;
- floor rings for fastening of freight – 6 pieces;
- plafond explosion-proof the PTE-Exd-15 brands (degree of protection of IP65) of internal illumination of body with isolation of wiring in aluminum housings – 1 set.;
- the installation of the Snow-storm-2 fire extinguishing system having autonomous power supply from the regular accumulator and which is put in action from driver's cab – 1 set
6. Completion of the basic vehicle:
- the exhaust system corresponds to ЕЭКООН No. 105;
- protection of the fuel tank the painted metal on perimeter, bottom is closed by perforated painted metal (with technological bore);
- installation of the switch for disconnection of electric circuit outside of the vehicle, and in driver's cab (degree of protection of IP54);
- LED flashing indicator of orange color on the magnetic base – 1 piece
- installation of the fire extinguishing system of the motor compartment "Doping-2".
- installation of device of speed limitation of 90 km/h.
7. Production and installation in load box of box for sand
8. Metal grounding chain with contact of the earth on length of 200 mm. grounding circuit (20 m)
9. Holographic danger signs with fastenings (framework - 2 pieces and set of figures 33 of the sign)
10. OP-5 fire extinguisher
11. Set of the tool for minor repair of the vehicle
12. First-aid kit automobile
13. Breakdown triangle
14. Signal of emergency stop
15. Sign "Entrance Is Forbidden"
16. Towing cable
17. Folding shovel
18. Antiretractable thrust blocks

Documents for statement of the car in bodies of traffic police
The LLC Spetstekhprom Company issues to all necessary documents for registration of the car for account: the Certificate on compliance of re-equipment of the car, N. Novgorod given by traffic police,
Mark in V/C - " car for transportation of dangerous freights, hazard class 1", corresponds on DOPOG EH/III, and ЕЭКООН 105).
You can call on all questions, documentary or technical, on number 8 831 233-03-13
We are professionals in the business!!!

The process of ordering machinery

1
Consultation on the car and equipment
2
Conference call with the Customer
3
Individual discount available
4
Conclusion of an agreement (contract)
5
Reconcile the 3D model with the design department
6
Start the production cycle
7
Readiness alert
8
Shipment date negotiation
9
Delivery
Services